The connection between the Electric Tricycle generator and the range extender battery should be firm

2025-09-29 15:06:49

The transmission line from the Three wheeled electric vehicle range extender generator to the distribution box or to all electrical mechanical equipment should have a good insulation layer, the joints should be firm, and the transmission line should be supported on the ground and should not be dragged on the ground.

During operation, if you want to check the motor commutator and electric slip ring, you should wear insulating gloves and rubber boots, and put a rubber mat on the wooden floor near the exciter and rotor and electric slip ring.

When using the Three wheeled vehicle range extender generator that has been out of service for a long time, the insulation level of the electromagnetic coil should be checked. The grounding resistance should not be less than the required specifications. Otherwise, it can only be used after air drying.

If it is disconnected suddenly, it will cause overvoltage and damage the electronic components of the generator or the Electric tricycle range extender controller.

Once a common fault is found in the DC motor or controller, it should be repaired immediately and fault detection should be performed immediately. It cannot continue to run.